Setup of Aerosol Delivery System to Prevent Measles Virus Infection in Nonhuman Primate Model.

Measles virus is one of the most contagious airborne human viruses which keeps causing outbreaks in numerous countries over the world despite the existence of an efficient vaccine. Fusion inhibitory lipopeptides were shown to inhibit viral entry into target cells, and their adequate administration into the respiratory tract may provide a novel preventive approach against airborne infections. Aerosol delivery presents the best administration route to deliver such preventive compounds to the upper and lower respiratory tract. This approach offers a conceptually new strategy to protect the population at risk against infection by respiratory viruses, including measles. It is a noninvasive needle-free approach, which may be used when antiviral protection is required, without any medical assistance. In this chapter, we describe the nebulization approach of lipopeptide compounds in nonhuman primates and the subsequent measles virus challenge.

Influence of mesh nebulizer characteristics on aerosol delivery in non-human primates.

Non-Human Primates (NHPs) are particularly relevant for preclinical studies during the development of inhaled biologics. However, aerosol inhalation in NHPs is difficult to evaluate due to a low lung deposition fraction and high variability. The objective of this study was to evaluate the influence of mesh nebulizer parameters to improve lung deposition in macaques. We developed a humidified heated and ventilated anatomical 3D printed macaque model of the upper respiratory tract to reduce experiments with animals. The model was compared to in vivo deposition using 2D planar scintigraphy imaging in NHPs and demonstrated good predictivity. Next, the anatomical model was used to evaluate the position of the nebulizer on the mask, the aerosol particle size and the aerosol flow rate on the lung deposition. We showed that placing the mesh-nebulizer in the upper part of the mask and in proximal position to the NHP improved lung delivery prediction. The lower the aerosol size and the lower the aerosol flow rate, the better the predicted aerosol deposition. In particular, for 4.3 ± 0.1 µm in terms of volume mean diameter, we obtained 5.6 % ± 0.2 % % vs 19.2 % ± 2.5 % deposition in the lung model for an aerosol flow rate of 0.4 mL/min vs 0.03 mL/min and achieved 16 % of the nebulizer charge deposited in the lungs of macaques. Despite the improvement of lung deposition efficiency in macaques, its variability remained high (6-21 %).

Association of forced oscillation technique measurements with respiratory system compliance and resistance in a 2-compartment physical model.

BACKGROUND: The forced oscillation technique (FOT) may be useful for diagnosis and follow-up of respiratory diseases. It is unclear how global or regional alterations in airway resistance (Raw) and lung compliance (CL) alter FOT measurements. METHODS: A 2-compartment physical model of the respiratory system allowed to simulate variations in Raw, CL, and their heterogeneity during tidal breathing in an adult human. Five-Hz respiratory system resistance (Rrs5) and reactance (Xrs5), area of reactance (AX), resonance frequency (Fresp) and intrabreath variation in Rrs5 and Xrs5 were measured by FOT. Frequency dependance of resistance could not be studied in this model. Relationships between model characteristics (Raw, CL, and heterogeneity) and FOT measurements were explored by multiple regression. RESULTS: Rrs5 and intrabreath variation in Rrs5 and Xrs5 strongly associated with model characteristics (R2=0.753, 0.5 and 0.658). Associations of Xrs5, AX, and Fresp with model characteristics were weak (R2=0.214, 0.349 and 0.076). Raw heterogeneity was the main determinant of Rrs5 (Coeff=0.594), AX (Coeff=0.566) and intrabreath variation in Rrs5 and Xrs5 (Coeff=0.586 and 0.732). Regional extremes in Raw strongly determined Rrs5 (Coeff=1.006). Xrs5 did not strongly associate with any model characteristic. CONCLUSION: Raw heterogeneity and maximal regional Raw were the main determinants of FOT measurements, in particular Rrs5. Associations between CL and FOT measurements were weak.

Administration of Bacteriophages via Nebulization during Mechanical Ventilation: In Vitro Study and Lung Deposition in Macaques.

Bacteriophages have been identified as a potential treatment option to treat lung infection in the context of antibiotic resistance. We performed a preclinical study to predict the efficacy of delivery of bacteriophages against Pseudomonas aeruginosa (PA) when administered via nebulization during mechanical ventilation (MV). We selected a mix of four anti-PA phages containing two Podoviridae and two Myoviridae, with a coverage of 87.8% (36/41) on an international PA reference panel. When administered via nebulization, a loss of 0.30-0.65 log of infective phage titers was measured. No difference between jet, ultrasonic and mesh nebulizers was observed in terms of loss of phage viability, but a higher output was measured with the mesh nebulizer. Interestingly, Myoviridae are significantly more sensitive to nebulization than Podoviridae since their long tail is much more prone to damage. Phage nebulization has been measured as compatible with humidified ventilation. Based on in vitro measurement, the lung deposition prediction of viable phage particles ranges from 6% to 26% of the phages loaded in the nebulizer. Further, 8% to 15% of lung deposition was measured by scintigraphy in three macaques. A phage dose of 1 × 109 PFU/mL nebulized by the mesh nebulizer during MV predicts an efficient dose in the lung against PA, comparable with the dose chosen to define the susceptibility of the strain.

Nebulized fusion inhibitory peptide protects cynomolgus macaques from measles virus infection.

Measles is the most contagious airborne viral infection and the leading cause of child death among vaccine-preventable diseases. We show here that aerosolized lipopeptide fusion inhibitor, derived from heptad-repeat regions of the measles virus (MeV) fusion protein, blocks respiratory MeV infection in a non-human primate model, the cynomolgus macaque. We use a custom-designed mesh nebulizer to ensure efficient aerosol delivery of peptide to the respiratory tract and demonstrate the absence of adverse effects and lung pathology in macaques. The nebulized peptide efficiently prevents MeV infection, resulting in the complete absence of MeV RNA, MeV-infected cells, and MeV-specific humoral responses in treated animals. This strategy provides an additional means to fight against respiratory infection in non-vaccinated people, that can be readily translated to human trials. It presents a proof-of-concept for the aerosol delivery of fusion inhibitory peptides to protect against measles and other airborne viruses, including SARS-CoV-2, in case of high-risk exposure.

Nebulized fusion inhibitory peptide protects cynomolgus macaques from measles virus infection.

Measles is the most contagious airborne viral infection and the leading cause of child death among vaccine-preventable diseases. We show here that aerosolized lipopeptide fusion inhibitors, derived from heptad-repeat regions of the measles virus (MeV) fusion protein, block respiratory MeV infection in a non-human primate model, the cynomolgus macaque. We used a custom-designed mesh nebulizer to ensure efficient aerosol delivery of peptides to the respiratory tract and demonstrated the absence of adverse effects and lung pathology in macaques. The nebulized peptide efficiently prevented MeV infection, resulting in the complete absence of MeV RNA, MeV-infected cells, and MeV-specific humoral responses in treated animals. This strategy provides an additional shield which complements vaccination to fight against respiratory infection, presenting a proof-of-concept for the aerosol delivery of fusion inhibitory peptides to protect against measles and other airborne viruses, including SARS-CoV-2, in case of high-risk exposure, that can be readily translated to human trials.

Inhaled bacteriophage therapy in a porcine model of pneumonia caused by Pseudomonas aeruginosa during mechanical ventilation.

BACKGROUND AND PURPOSE 255: Pseudomonas aeruginosa is a main cause of ventilator-associated pneumonia (VAP) with drug-resistant bacteria. Bacteriophage therapy has experienced resurgence to compensate for the limited development of novel antibiotics. However, phage therapy is limited to a compassionate use so far, resulting from lack of adequate studies in relevant pharmacological models. We used a pig model of pneumonia caused by P. aeruginosa that recapitulates essential features of human disease to study the antimicrobial efficacy of nebulized-phage therapy. EXPERIMENTAL APPROACH: (i) Lysis kinetic assays were performed to evaluate in vitro phage antibacterial efficacy against P. aeruginosa and select relevant combinations of lytic phages. (ii) The efficacy of the phage combinations was investigated in vivo (murine model of P. aeruginosa lung infection). (iii) We determined the optimal conditions to ensure efficient phage delivery by aerosol during mechanical ventilation. (iv) Lung antimicrobial efficacy of inhaled-phage therapy was evaluated in pigs, which were anaesthetized, mechanically ventilated and infected with P. aeruginosa. KEY RESULTS: By selecting an active phage cocktail and optimizing aerosol delivery conditions, we were able to deliver high phage concentrations in the lungs, which resulted in a rapid and marked reduction in P. aeruginosa density (1.5-log reduction, p < .001). No infective phage was detected in the sera and urines throughout the experiment. CONCLUSION AND IMPLICATIONS: Our findings demonstrated (i) the feasibility of delivering large amounts of active phages by nebulization during mechanical ventilation and (ii) rapid control of in situ infection by inhaled bacteriophage in an experimental model of P. aeruginosa pneumonia with high translational value.

Low-Frequency Intrapulmonary Percussive Ventilation Increases Aerosol Penetration in a 2-Compartment Physical Model of Fibrotic Lung Disease.

In patients with fibrotic pulmonary disease such as idiopathic pulmonary fibrosis (IPF), inhaled aerosols deposit mostly in the less affected region of the lungs, resulting in suboptimal pharmacokinetics of airway-delivered treatments. Refinement of aerosol delivery technique requires new models to simulate the major alterations of lung physiology associated with IPF, i.e., heterogeneously reduced lung compliance and increased airway caliber. A novel physical model of the respiratory system was constructed to simulate aerosol drug delivery in spontaneously breathing (negative pressure ventilation) IPF patients. The model comprises upper (Alberta ideal throat) and lower airway (plastic tubing) models and branches into two compartments (Michigan lung models) which differ in compliance and caliber of conducting airway. The model was able to reproduce the heterogeneous, compliance-dependent reduction in ventilation and aerosol penetration (using NaF as a model aerosol) seen in fibrotic lung regions in IPF. Of note, intrapulmonary percussive ventilation induced a 2-3-fold increase in aerosol penetration in the low-compliance/high airway caliber compartment of the model, demonstrating the responsiveness of the model to therapeutic intervention.

Effect of three-drug delivery modalities on olfactory function in chronic sinusitis.

BACKGROUND: Olfactory dysfunction is deemed to be a significant contributor to poor quality of life in chronic rhinosinusitis (CRS). OBJECTIVE: To assess and to compare the effectiveness of three modalities of corticosteroids administration in patients with CRS. STUDY DESIGN: A prospective randomized controlled study METHODS: Thirty patients with CRS were randomized in three groups depending on the route of corticosteroids administration: 16 days by oral route (Medrol (Pfizer, Belgique), 32 mg/8 days -16 mg/4 days-8 mg/4 days); nasal spray (Rhinocort (AstraZeneca, Belgique), 2 × 2 × 64 µg/nostril); or sonic nebulization (Pulmicort (AstraZeneca, Belgique), 2 × 1 mg/4 mL) (Sonic nebulizer, AOHBOX-NL11SN, DTF, France). Olfactory function was assessed using orthonasal threshold discrimination identification and retronasal psychophysical olfactory tests (RNT) before and after the treatment. Same intranasal modalities were previously tested for in vitro airways scintigraphic deposition. RESULTS: In vitro differences in drug deposition pattern between both intranasal modalities were demonstrated. Threshold discrimination identification and RNT were similar between three groups at baseline. Threshold discrimination identification improved by 5.5, 5.8, and -1.1 for sonic nebulization, oral, and nasal spray groups, respectively (P = 0.010). This improvement was clinically relevant for oral and nebulized administration. It was similar between oral and nebulized administration but significantly higher than nasal spray administration. Retronasal psychophysical olfactory tests improved similarly for the three groups (P = 0.231) CONCLUSION: Effectiveness of sonic nebulized and oral administration is demonstrated on orthonasal olfactory. The clinical benefit is better than with nasal spray.

Assessing sinus aerosol deposition: benefits of SPECT-CT imaging.

PURPOSE: Aerosol inhalation therapy is one of the methods to treat rhinosinusitis. However the topical drug delivery to the posterior nose and paranasal sinuses shows only limited efficiency. A precise sinusal targeting remains a main challenge for aerosol treatment of sinus disorders. This paper proposes a comparative study of the nasal deposition patterns of micron and submicron particles using planar gamma-scintigraphy imaging vs. a new 3-dimensional (3D) imaging approach based on SPECT-CT measurements. METHODS: Radiolabelled nebulizations have been performed on a plastinated model of human nasal cast coupled with a respiratory pump. First, the benefits provided by SPECT-CT imaging were compared with 2D gamma-scintigraphy and radioactive quantification of maxillary sinus lavage as reference for the sonic 2.8 µm aerosol sinusal deposition. Then, the impact on nasal deposition of various airborne particle sizes was assessed. RESULTS: The 2D methodology overestimates aerosol deposition in the maxillary sinuses by a factor 9 whereas the 3D methodology is in agreement with the maxillary sinus lavage reference methodology. Then with the SPECT-CT approach we highlighted that the higher particle size was mainly deposited in the central nasal cavity contrary to the submicron aerosol particles (33.8 ± 0.6% of total deposition for the 2.8 µm particles vs. 1 ± 0.3% for the 230 nm particles). CONCLUSION: Benefits of SPECT/CT for the assessment of radiolabelled aerosol deposition in rhinology are clearly demonstrated. This 3D methodology should be preferentially used for scintigraphic imaging of sinusal deposition in Human.

Validation of anatomical models to study aerosol deposition in human nasal cavities.

PURPOSE: Intranasal deposition of aerosols is often studied using in vitro nasal cavity models. However, the relevance of these models to predict in vivo human deposition has not been validated. This study compared in vivo nasal aerosol deposition and in vitro deposition in a human plastinated head model (NC1) and its replica constructed from CT-scan (NC2). METHODS: Two nebulizers (Atomisor Sonique® and Easynose®) were used to administer a 5.6 µm aerosol of (99m)Tc-DTPA to seven healthy volunteers and to the nasal models. Aerosol deposition was quantified by γ-scintigraphy in the nasal, upper nasal cavity and maxillary sinus (MS) regions. The distribution of aerosol deposition was determined along three nasal cavity axes (x, y and z). RESULTS: There was no significant difference regarding aerosol deposition between the volunteers and NC1. Aerosol deposition was significantly lower in NC2 than in volunteers regarding nasal region (p < 0.05) but was similar for the upper nasal cavity and MS regions. Mean aerosol distribution for NC1 came within the standard deviation (SD) of in vivo distribution, whereas that of NC2 was outside the in vivo SD for x and y axes. CONCLUSIONS: In conclusion, nasal models can be used to predict aerosol deposition produced by nebulizers, but their performance depends on their design.

Impact of acoustic airflow nebulization on intrasinus drug deposition of a human plastinated nasal cast: new insights into the mechanisms involved.

PURPOSE: The impact of 100 Hz (Hertz) acoustic frequency airflow on sinus drug deposition of aerosols was investigated using a human plastinated nasal cast. The influence of drug concentration and endonasal anatomical features on the sinus deposition enhanced by the 100 Hz acoustic airflow was also examined. METHODS: Plastinated models were anatomically, geometrically and aerodynamically validated (endoscopy, CT scans, acoustic rhinometry and rhinomanometry). Using the gentamicin as a marker, 286 experiments of aerosol deposition were performed. Changes of airborne particles metrology produced under different nebulization conditions (100 Hz acoustic airflow and gentamicin concentration) were also examined. RESULTS: Aerodynamic and geometric investigations highlighted a global behaviour of plastinated models in perfect accordance with a nasal decongested healthy subject. The results of intrasinus drug deposition clearly demonstrated that the aerosols can penetrate into the maxillary sinuses. The 100 Hz acoustic airflow led to increase the deposition of drug into the maxillary sinuses by a factor 2-3 depending on the nebulization conditions. A differential intrasinus deposition of active substance depending on maxillary ostium anatomical features and drug concentration was emphasized. CONCLUSION: The existence of a specific transport mechanism of penetration of nebulized particles delivered with acoustic airflow was proposed.

Deposition of aerosols delivered by nasal route with jet and mesh nebulizers.

PURPOSE: To quantify the amount of aerosol deposited in different parts of the airways with a commercially available nasal sonic jet nebulizer (NJN) using a sound effect, and to compare its performance with a new nasal mesh nebulizer (NMN). METHODS: Seven healthy non-smoking male volunteers aged 21-36 years with a mean weight of 77±10 kg were included in this single-center study. Both nebulizer systems were loaded with (99m)Tc-DTPA and scintigraphies were performed with a gamma camera. Particle size distribution of the aerosols produced by the two nebulizer systems was measured. RESULTS: There was no statistical difference between the two nebulizers in terms of fraction of particles smaller than 5 µm (44±4% vs 45±2%) (p>0.9). Aerosol deposition in the nasal region was 73±10% (% of aerosol deposited in airways) with the NJN, and 99±3% with the NMN (p=0.01). Total nasal deposition was 9.6±1.9% of the nebulizer charge with the NJN and 28.4±8.9% with the NMN (p=0.01). 0.5±0.3% of the nebulizer charge was deposited in the maxillary sinuses with the NJN, compared to 2.2±1.6% with the NMN (p=0.01). CONCLUSION: Although the two nebulizers had the same particle size, NMN significantly improved aerosol deposition in nasal cavity and prevents deposition into the lungs.

Evaluation of lung tolerance of ethanol, propylene glycol, and sorbitan monooleate as solvents in medical aerosols.

BACKGROUND: Aerosol therapy is an expanding technique allowing administration of drugs acting locally in the bronchial tree and lungs or acting systemically after absorption through the respiratory tract. However, the choice of solvents and adjuvants is a critical step in the formulation process of new drugs. Pulmonary tolerance of ethanol, propylene glycol and sorbitan ester was evaluated in a rat model of intratracheal administration using a Microsprayer in a 4-day toxicity study. METHODS: Four groups of Sprague-Dawley rats (11 rats per group, n = 44) have received, on 4 consecutive days 150 microL of solutions containing the solvents, by intratracheal route using a IA-1B-2 inches-Microsprayer (PennCentury, Philadelphia, PA). Once a day, the rats received deionized water (control) or ethanol 10% or propylene glycol 30% or sorbitan monooleate 10%. All rats were sacrificed 24 h after the fourth administration. Biochemical analysis on bronchoalveolar lavage (BAL) fluid was performed on seven rats per group. The respiratory tract of the remaining four rats/group was examined histologically. RESULTS: Biochemistry and histopathology findings demonstrated that under the conditions tested, deionized water, 10% ethanol, and 30% propylene glycol were tolerated in a qualitatively similar way presenting limited cellular reaction. In contrast, 10% sorbitan monooleate produced an accumulation of foamy macrophages in the lungs and a higher degree of inflammation. In addition, animals in this group showed higher polymorphonuclear neutrophil recruitment and total proteins levels in BAL fluid. CONCLUSION: The overall results recommended ranking the vehicles according to the degree of inflammation which was induced: deionized water <10% ethanol < or =30% propylene glycol <10% Tween 80.

Aerodynamical, immunological and pharmacological properties of the anticancer antibody cetuximab following nebulization.

PURPOSE: Despite an increasing interest in the use of inhalation for local delivery of molecules for respiratory diseases and systemic disorders, methods to deliver therapy through airways has received little attention for lung cancer treatment. However, inhalation of anticancer drugs is an attractive alternative route to systemic administration which results in limited concentration of the medication in the lungs, and triggers whole-body toxicity. In this study, we investigated the feasibility of nebulization for therapeutic antibodies, a new class of fully-approved anticancer drugs in oncology medicine. MATERIALS AND METHODS: Cetuximab, a chimeric IgG1 targeting the epidermal growth factor receptor (EGFR), was nebulized using three types of delivery devices: a jet nebulizer PARI LC+, a mesh nebulizer AeronebPro and an ultrasonic nebulizer SYST'AM LS290. Aerosol size distribution was measured using a cascade impactor and aerosol droplets were observed under optical microscopy. The immunological and pharmacological properties of cetuximab were evaluated following nebulization using A431 cells. RESULTS: The aerosol particle clouds generated with the three nebulizers displayed similar aerodynamical characteristics, but the IgG formed aggregates in liquid phase following nebulization with both the jet and ultrasonic devices. Flow cytometry analyses and assays of EGFR-phosphorylation and cell growth inhibitions on A431 demonstrated that both the mesh and the jet nebulizers preserved the binding affinity to EGFR and the inhibitory activities of cetuximab. CONCLUSIONS: Altogether, our results indicate that cetuximab resists the physical constraints of nebulization. Thus, airway delivery represents a promising alternative to systemic administration for local delivery of therapeutic antibodies in lung cancer treatment.

Lung deposition of HFA beclomethasone dipropionate in an animal model of bronchopulmonary dysplasia.

The best delivery of a drug in ventilated neonates is obtained when using a small particle diameter solution administered via a spacer. Lung deposition of hydrofluoroalkane beclomethasone dipropionate (QVAR, 1.3 microm particles), delivered via an Aerochamber-MV15, was measured in piglets under conditions mimicking ventilated severely ill neonates (uncuffed 2.5 mm endotracheal tube; peak pressure 16 cm H2O; respiratory rate 40/min). After determining the mass and particle size distribution of the 99mTc-labeled and unlabeled drug, three lung deposition studies were performed: after 1 h of ventilation (controls, n = 18), after 48 h aggressive ventilation inducing an acute lung injury (nine piglets out of the controls), and after increasing the pressure to 24 cm H2O during drug delivery (five piglets out of the nine with acute lung injury). All piglets were then killed for lung histology. Results (median, range), expressed as a percentage of the delivered dose, were compared using an inferential or the Friedman test. While lung deposition was low, it was greater (p = 0.003) in controls (2.66%, 0.50-7.70) than in piglets with histologically confirmed acute lung injury (0.26%, 0.06-1.28) or under a high-pressure ventilation (1.01%, 0.30-2.15). Lung deposition of QVAR in an animal model of ventilated neonates is low, variable, and dramatically affected by lung injury.